128 Point Safety Inspection

Road Test                            

  • Check Engine
  • Engine Cold High Idle Normal
  • Noise In Engine
  • Throttle Does Not Stick
  • Engine Function During Warm-Up is Normal
  • Engine Reaches Normal Op Temp.
  • Fans Work Properly
  • Brake Pedal Travel Normal
  • Vibration During Braking
  • Abs Normal
  • Parking Brake Holds Vehicle
  • Transmission Shifts Smoothly
  • Auto Transmission In ECT Shifts
  • Transmission Gears Engage
  • Trans. Shift Lock & Key Interlock
  • Transmission Shifts Into Overdrive
  • Steering Normal In Lock-Lock Turning
  • Steering Wheel Centered In Line
  • Steering Tracks Straight
  • Tilt Steering Normal
  • Speedometer Functions Properly
  • No Drone/Vibration From Engine
  • No Wind, Whistle or Buzz
  • No Tire/Steering Vibration
  • Interior Trim In Place
  • Check Engine Light

   Frame & Under-body

  • Frame/Uni-body Check
  • Body Surface
  • Panel Alignment
  • Lower/Under Body For Damage
  • Steering Rack, Dust Boots, Linkage, Bushings & Control Arms
  • Transmission Case & Pan
  • Oil Pan
  • Suspension Check

 Engine Compartment

  • Perform Emissions Test and/or State Inspection If Required
  • Drive Belts Are Free Of Cracks
  • Check Under Hood Labels & Decals
  • Check Air Filter
  • Engine Coolant At Proper Hot & Cold Levels
  • Coolant Specific Gravity To -31 Degrees Fahrenheit
  • Oil, Brake, Clutch, Washer, Trans., Transfer Case, Power Steering Fluids
  • Under-Hood Fluids Clear & Uncontaminated
  • Removal Of Unacceptable After Market Items

Safety Items                           

  • Seat Belt Condition
  • Seat Belts Normal Range Extension and Smooth
  • Seat Belts Lock Up
  • All Wipers Speeds
  • Windshield Washer Operation
  • Wiper Blades Working In Good Condition
  • Wipers Return To Correct Position When Off
  • Tire Defects, Damage & Inflation
  • Min. 4/32 Tread Depth Across Tread Width
  • All Tires Same Size
  • Brakes, Calipers, Lines & Hoses
  • Brake Pads/Shoes Min. 50% Wear Remaining
  • No Excessive Grooving or Heat Checking Of Rotor-Drums
  • Parking Brake Releases Completely
  • Struts/Shocks
  • Exhaust Systems & Hangers
  • Damage To Engine Mounts
  • Check Drive-Axle Shafts
  • CV Joints & Boots
  • Fuel, Oil, Coolant or Other Leaks
  • Differential Fluid Level Correct
  • Check for Evidence Of Sludge
  • Change Oil & Filter
  • Battery- Proper Cold Cranking Amps & Reserve
  • Battery Proper Size & Secure
  • Cables In Good Condition
  • Battery Posts Free Of Corrosion
  • Horn Works
  • Air Bags
  • High & Low Beams
  • Headlight Aim
  • Tail Lights
  • Brake Lights
  • Side Marker Lights
  • Backup Lights Work
  • License Plate Lights
  • No Cracked or Broken Lenses Of Exterior Lights
  • Instrument Lights Work
  • Heater Lights Work
  • Dash Light Dimmer
  • Turn Signals Operate & Self-Cancel
  • Four-Way Flashers Work
  • Day-Night Mirror Works & Lens
  • Outside Rear View Mirror Operates/Lens
  • All Mirrors Have Full Range Of Adjustment
  • All Glass Free Of Cracks, Stars & Large Chips

Accessories

  • Heater Operation
  • Radio Speakers Do Not Rattle
  • Wheel Cover Caps Secure
  • A/C Cooling Operation
  • A/C Refrigerant Sight Glass Clear
  • Warning Lights Function
  • Fuel Gauge Reads Correctly
  • Battery Voltage Gauge Reads Correctly
  • Window Tinting is Legal
  • Dome/Courtesy Lights Operates
  • Windows Operate Normally
  • Window Locks Operate Normally
  • Power Windows Operate From Master Switch & All Door Switches
  • 4x4 Engages Normally
  • Audio System Operating Normally
  • Cigarette Lighters Intact & Working
  • Ashtrays Function and Are In Good Condition
  • Head Liner, Sun Visors, Dash Pad, Console, Upholstery, Cup Holders, Trim Panels, Carpets All In Place
  • Cup Holders Extend & Sturdy
  • Doors Open & Close Correctly
  • Door Locks & Child Safety Locks
  • Key Is Present
  • Seats In All Positions, Adjusters Work
  • Acceptable After Market Items Checked
  • Headrests Are Present & Function Normally
  • Defogger Light Turns On With Switch On
  • Rear Defogger Grid Lines Intact
  • Trunk Light, Trunk Trim Operation
  • Fiber Board Tire Cover Is Not Broken
  • Hood Latch, Trunk Latch
  • Inside Trunk Remote
  • Spare Tire Present
  • Minimum MA State Requirement Tread Remaining On Spare
  • Spare Tire Has Correct Air Pressure
  • No Sign Of Damage To Spare Tire
  • Jack & Tools Are Correct, Present & Secured